Repair Products
We have made available for all you "fix-it-yourselfers" many necessary products to keep your Chimney and Fireplace it tip-top condition! Below you will find several silicone caulks, fireplace mortar caulk, furnace cement, refractory cement, dry mix cement, Fiberglas insert seal, stove gasket, stove gasket cement, and dry graphite lube. Also available below:
Other products are available in Cleaners, Creosote Removers, Crown & Chimney Repair, Gas Leak & Smoke Detectors, Replacement Screens and Paints. Check Out our wide selection of Chimney Caps, Fireplace Accessories, Hearth Accessories, Home Safety Products and Dryer Vent Products.
RTV SILICONE- 50 Year Life;ITEM #322 CLEAR OR #323 BLACK @ $12.00
Silicone is the general adhesive and sealant of choice for chimney pro's. Because it bonds to just about anything, stays elastic and with stands temperatures 400*F constant, it's used for about everything except firebox repair! Comes in either clear or black in an easy to use caulk tube.
RTV RED SILICONE SEALANT; ITEM #747@ $23.95
RUTLAND FIREPLACE MORTAR; ITEM #721-GRAY, #722-BUFF, #720-BLACK @ $8.50
It is an excellent product to tuck-point between firebricks and repair broken firebricks. (Maximum application thickness is 1/8") Contains no asbestos. Designed especially to patch fireplace fireboxes, bonding firebrick to firebrick. A silicate product that when fire cured, sets rock hard - as strong as firebrick itself. Withstands 2000*F. Comes in three colors: Gray, Buff, and Black. Not for exterior use.
IPC FURNACE CEMENT; 1 and 2 GALLON BUCKETS
Ideally, IPC Furnace Cement should be applied in temperatures above freezing. But it does have a chemical additive that inhibits freezing, making it possible to apply in temperatures down to 0 degrees F. It has a maximum application thickness of 1/4". Comes in 1 and 2 gallon buckets.
RUTLAND FURNACE CEMENT-Black; ITEM #81130-PINT TUB @ $7.75
FURNACE CEMENT; ITEM #724-PINT @ $9.50
#725-QUART @ $15.50
REFRACTORY CEMENT; Comes in 1/2 Gallon or (2) 1 Gallon Pails
Buff-colored and comes in 1/2 gallon tubs or cases of two 1 gallon tubs. ITEM #81155, 1/2 GALLON PAIL @ 19.50 ITEM #81156 CASE OF (2) GALLON PAILS @ 57.50
CASTABLE REFRACTORY CEMENT; ITEM #81153 (CASE OF 2 GALLON PAILS) @$88.00
Originally developed for use in blast furnaces, this product as unbelievable strength. It can withstand temperatures up to 2200 degrees. Sold incases of two, each 1 gallon container (12.5 lbs.) covers one square foot at 1 1/2" depth when mixed with one quart of water. Easy directions on the container. DRY MIX 211; ITEM #761 GALLON @ $34.00
SUPER 3000 CEMENT; 25 LB/55LB CONTAINERS
Super 3000 Cement is gray in color and has a sodium silicate binder which eliminates the need to dampen the brick during application. This makes it shrink resistant while giving it exceptional strength and workability. Super 3000 Cement is available in two formulas, Troweling and Parging. The Super 3000 Cement for Troweling is without grit. The Super 3000 With Grit for parging contains sand to give it a gritty consistency. Both should be stored in an area where the temperature is above freezing, yet not above 90 degrees. If product freezes during shipping, it should be thawed and thoroughly mixed before using. Coverage is 4-6 sq. ft. per gallon when applied to a thickness of 1/8" to 1/4" thick. Available in 25 lb. and 55 lb. pails.
HomeSaver FLUE GOO; 1/2 GALLON, 1 GALLON AND 3 1/2 GALLON TUBS
Flue Goo will withstand temperatures up to 3000 degrees F without cracking or shrinking. On the other end of the temperature spectrum, Flue Goo is freeze/thaw stable; however it's still a good idea to bring it indoors in freezing weather. Flue Goo contains no asbestos. It comes premixed and ready to use , and is water-soluble for easy cleanup. Comes in three colors: black, buff, and gray. It's packed in 1/2 gallon, 1 gallon and 3 1/2 gallon plastic tubs. It is not for exterior use.
HomeSaver FLUE GOO II NON-WATER SOLUBLE REFRACTORY CEMENT; ITEM #29400 @ $28.00
Flue Goo II is a specially designed, gray-colored refractory cement that is nonwater-soluble after drying. Use Flue Goo II for flue tile installations, as well as for setting firebrick and parging the walls of smoke chambers. It's sold in powder form in resealable, 1 gallon plastic tubs. Each gallon will set about 10 - 20 flue tiles. 30 firebrick, or will cover 4-6 sq. ft. when parged to a thickness of 1/8" - 1/4". Not for exterior use.
FIBERGLASS INSERT SEAL; ITEM #81210 @ $21.95
17. STOVE GASKET KITS; ITEM #745-7'5/16"ROPE, #744-7'5/8"ROPE, #748-7'5/8"ROPE, #746-7'3/8"ROPE @ $18.99
STOVE & GASKET CEMENT; ITEM #81136-3FL. OZ @ $7.25
HomeSaver Replacement
Fiberglass Stove Gasket and Cement is easy to install.
Simply remove the old, worn, frayed gasket, clean the
surface and glue in a new gasket. You'll need a tube of
cement to do the job. Bad stove gaskets lead to incomplete
combustion, as well as wasted heat and fuel.
Choose exactly the right replacement from our
most popular sizes and shapes listed below. These
gaskets are braided, not coiled so they are not easily
unraveled. HomeSaver Stove Gasket Cement;
 ITEM #81300-3 fl.oz
tube @ $6.05
REPLACEMENT FIBERGLASS STOVE GASKET PACKETS
GRIDDLE GASKET FOR VERMONT CASTINGS STOVES;ITEM #81275 @ $9.95
19. ONE MATCH Gelled Firestarter; ITEM #762-16oz.bottle @ $12.00 25. 204 DRY GRAPHITE LUBE; ITEM #603-10
FL OZ SPRAY CAN @ 17.00 Most of the time when repairing curtain screens you will find that the screen itself is ok. What has happened is the rod the screen runs on has not been lubricated since installation. It is now rusted and makes the loops that hold the screen up sticky. Home owner pulls harder, things break! This is a high-temp Graphite spray on lube (good to 1000 deg. F) that will make the screen move freely again. Just spray the rod the screen runs on (use a piece of cardboard to catch the over spray), then replace the broken or missing rings (some bailing wire works good) that hold the screen to the rod and any screen pulls if necessary and you will have a smooth running screen assembly. This product will have a lot of uses other than making screen run smoothly. How many places around a fireplace haven't been lubed since it was built? Temperatures up to 850°F constant and 1000°F
intermittent. |
(room
temperature vulcanized-it cures at room temperature)
This is the red silicone that is rated at 550*F
continuous and 600*F intermittent. RTV stands for "room temperature
vulcanize" (it cures at room temperature). So when you
need the highest temperature rating, this is the one to
use.
You know what can happen when you fail to repair one or two
eroded or weakened mortar joints in a fireplace - it can set off a
chain reaction of deterioration that leaves the firebox a real mess.
Perform the needed repairs with a Rutland Fireplace
Mortar. 
What sets IPC Furnace Cement apart is its
texture. It is smooth and creamy with absolutely no
grit. IPC bonds metal to metal, metal to masonry,
and masonry to masonry. It will not sag, crack, crumble,
shrink, or pull away when used in accordance with the instructions
on the label. IPC Furnace Cement is premixed and gray in
color. It is designed to withstand temperatures up to 3000
degrees F and seal against heat, vapor and steam.
Rutland Furnace Cement is a premixed silicate cement
that withstands temperatures over 2000 degrees F without
failure. It adheres to firebrick, as well as metal and seals
all types of stovepipe joints. It's black, non-gritty,
non-asbestos formula feathers very thin to make metal-to-metal
joints smoke and gas tight. Use during installation and
service of furnaces, stokers, oil burners, and small woodstove
repairs. Apply 1/16" - 1/4" thick. Comes in 1 pint
tubs. 
A ready-mixed
all-purpose, high-temperature resistant furnace/refractory
cement. It will bond masonry to masonry, steel to steel, and
steel to masonry. It is not for exterior use. Withstands
temperatures over 2700*F +. Gray in color. Each gallon will
set 30 firebrick, or cover 4-6 sq. ft. when parged to a thickness of
1/8" to 1/4". Comes in resealable plastic tubs. This is
the perfect cement for all interior firebox
repairs. 
This premixed cement is used for setting and
bonding firebrick in fireplaces, furnaces, stoves, and
incinerators.
Make your own firebrick with Rutland's Castable
Refractory Cement. When mixed with water, it sets to a light
brown color, hard as brick. Use it for replacing worn-out
firebrick in the bottom of woodstoves, cast it into irregular
shapes, or use it as a solid stone bed.
Just mix with water to produce a refractory
mortar that meets or exceeds MFPA 211, 1988 Edition. Used for
laying up masonry flue liner in fireplace chimneys, wood stoves,
coal stoves, pellet stoves, inserts, etc, Non water
soluble. 
The
best application for this product is a masonry to masonry
bond. Super 3000 Cement is premixed air and heat setting
mortar which withstands temperatures up to 3000 degrees F and
resists freezing down to 0 degrees F.
Flue Goo is a multi-purpose furnace/refractory
cement. It will bond masonry to masonry, steel to steel and
steel to masonry. 
Section 4-2-3 of NFPA 211 states that clay flue
liners must be imbedded in a nonwater-soluble calcium aluminate
refractory cement mixture..." Flue Goo II is such a
mixture. 
Lots of uses for this great product -Ten foot by 1 1/2" wide self-adhesive strip insulation
forms a smoke and gas tight seal between insert and existing
masonry. It's perfect for restoring the seal between the
fireplace insert and the hearth. Is also works between glass
doors front and rock face. See more Insulation on our 
Repair kit for replacing worn or burnt-out
gaskets on air-tight stoves, furnaces or fireplace inserts.
Enough gasket and cement for the average air-tight
stove. 
A black silicate-ceramic stove cement
adheres all types of gasket materials to airtight stoves, cements
cracks in metal, bonds metal to metal and Fiberglas to metal.
Good to 2000*F. 
ITEM #765-11 fl.oz tube for caulk gun @
$10.50
This gasket is for replacing worn or burnt out gaskets
around the windows in the frame of a stove door.
Peel-and-stick adhesive for easy installation. Just remove the
glass, clean it, encase the edges in the gasket and push back into
the frame. 
Packaged individually, this 5/16" stainless,
mesh-covered rope gasket is 50" long - an exact replacement for worn
or missing griddle gasket. 
One ounce of this gelled alcohol product lights
even the toughest fire. Will not affect catalytic
combustors. 
